Jeep yj fuel return line.

Sort. Crown Automotive 20 Gallon Fuel Sending Unit for 87-90 Jeep Wrangler YJ with 4.2L Engine. In Stock. $113.99. 4.272725. (11) Crown Automotive Fuel Sending Unit and Fuel Pump for 87-90 Jeep Wrangler YJ with 2.5L 4 Cylinder Engine & 15 Gallon Fuel Tank. In Stock. $150.99. Fuel line replacement. With the nice weather, I decided to check a couple things off the list in anticipation of driving the jeep when the weather gets better. I went to start the jeep to run the fluids and charge the battery and climbed underneath to inspect potentially starting the leaf spring replacement. I smelled gas and noticed a pretty ...I've got an 88 Wrangler 2.5 EFI 5 spd. There are no visible disconnected hoses or ports at the engine that I can find. The FSM doesn't provide any documentation on fuel line routing, connections, etc, and I cannot find a fuel line schematic anywhere. I've got the metal return line capped for now, but it really should be properly connected.Heated them with a heat gun to bend them to shape and install the new Dorman quick disconnects. The pressure line has a 5/16" quick disconnect and the return is an odd 3/8" quick disconnect that steps down to a 5/16" line. The rubber lines were replaced with 5/16" fuel injection hose and fuel injection clamps.It is a proprietary piece of fuel line you cant buy off the shelf i used to buy them from the dealer for about $90. I think they are available aftermarket now but i cant seem to find it now. 94, 4.0/NV4500/NP231HD w/JB Conversions super short SYE, 4.5" Rubicon Express lift, JKS 1.25" body lift, Dana 489's w/OX lockers 4.88 gears, Tom Woods ...

24. 6100047. NUT, Clip Mounting. MSRP: $8.25. $5.62. Add To Cart. Genuine Mopar Parts, the Right Choice. MoparPartsGiant .com offers the wholesale prices for genuine 1992 Jeep Wrangler parts. Parts like Fuel Line are shipped directly from authorized Mopar dealers and backed by the manufacturer's warranty. The return line also should be on the top side of the filter, above the carb line to prevent gas siphoning back to the tank when it sits, making for long cold starts. Mike 86/00 CJ7 Laredo, 33x9.5 BFG AT's, 'glass nose to tail in '00, 'New' frame,wires and plumbing in '09.41703. Comon guys YJ's use a return line, TJ's do not. Most of the manufactures switched at the OBD1/OBD11 transition. I own a 93 YJ and a 99TJ, YJ's have a regulator on at the fuel rail with the return going back to the tank and TJ's have a single feed line with all regulation in the tank as part of the sending unit.

OMIX Front Fuel Supply Line for 94-98 Jeep Cherokee XJ, Grand Cherokee ZJ & Wrangler YJ with 4.0L Engine. In Stock. $52.99. 4.5 (4) ... Classic Tube Fuel Return Line for 1994 Jeep Wrangler YJ with 20 Gallon Fuel Tank. Ships from 3rd Party. $79.99. Classic Tube Fuel Vapor Line for 1989 Jeep Wrangler YJ with 4.2L.Here is a number to call if you or any of the readers care to set your Weber up with it. 877-333-3130 B.F.I.C. aka Burbank Fuel Injection Company, these folks are VERY friendly and customer service orientated. That needle will withstand all that an OEM pump can deliver when used with the OEM fuel return system.

OMIX Front Fuel Supply Line for 94-98 Jeep Cherokee XJ, Grand Cherokee ZJ & Wrangler YJ with 4.0L Engine. In Stock. $52.99. 4.5 (4) ... Classic Tube Fuel Return Line for 1994 Jeep Wrangler YJ with 20 Gallon Fuel Tank. Ships from 3rd Party. $79.99. Classic Tube Fuel Vapor Line for 1989 Jeep Wrangler YJ with 4.2L.Replacing fuel check-valve on Wrangler. My wrangler doesn't start on the first try anymore. I turn the key and it just cranks. I wait a second and boom, it starts right up. It was suggested that my fuel check valve has gone bad and needs to be replaced. As far as I can tell, that check valve is in the top of the gas tank.Wrangler YJ (Model years 1987–1996) YJ Technical Discussion. Fuel line size. Jump to Latest Follow 12K views 1 ... I'm having a Jeep delivered to me tomorrow, '91 Wrangler 4.0 5spd. It is leaking fuel out the pressurized hose coming from …1987-1990 Wrangler 4.2 YJ Fuel Line Routing. Hello! I recently bought a YJ that the previous owner did an electric fuel pump conversion. I want to remove this fuel pump and convert it back into the mechanical type pump, but I am unsure of how the new lines should be routed with the fuel delivery, return, and fuel vapor line from the carb.

Another lesser known factor one reaps when the return line recirculates unused fuel back to the tank is that the fuel doesn't get heat soaked setting in the line to get used. The engine "grabs what it needs" and sends the unused back to the cool gas tank for recirculation...less chance for engine vapor lock.

Reads as though you're running low on fuel which is either the float, the screws settings, supply blockage or pump failure. Number one thing to do for the time being is to eliminate the FPR and restore the dual outlet fuel filter and the fuel return line.

The Ford Triton V-10 motor used in the F-250 pickup truck returns an average of approximately 10 miles per gallon based on user-reported fuel consumption figures.3 posts · Joined 2016. #1 · Nov 28, 2016. Hi all, I'm having trouble finding a replacement part for my 1995 Wrangler YJ 2.5. It's the auto transmission cooler hose - specifically the 624-083 Dorman part, which is itself a replacement for the 52079387 part which used to be available via Mopar. Two eBay sellers have sold and then cancelled …Feb 12, 2020 · Only one pressure line, other two are evap lines I think. fuel return will be added after I add the novak kit. O. ol rob. 68 posts · Joined 2019. #3 · Feb 13, 2020. I ran a 6AN pressure line from the LS regulator to the engine and completely removed all of the Jeep fuel system. I also made the short return like Novak suggests. Reads as though you're running low on fuel which is either the float, the screws settings, supply blockage or pump failure. Number one thing to do for the time being is to eliminate the FPR and restore the dual outlet fuel filter and the fuel return line.The hose that connect where the fuel pressure regulator is the return line. It acts like a plug that stops return if pressure is too low. '91 YJ Sahara 4.0L/AX-15/NP231, D30/D35 @3.07

Jeeps, we have them ... Working on the gas tank on our 81'. I know it's fed up the passenger side to the pump on this and my CJ7'. I have a return ...Return line at 0psi so that looks clear. Checked temp sensor and ohm readings go down when warm. Map sensor checks OK. Grounds and voltage to the ECM is good. New coil and timing set at 8 BTDC Vacuum lines are all new and confirmed correctly hooked up. When I installed the used kit I used new O2, Coolant sensor, and fuel filter.34. 34202728. CLIP. Genuine Mopar Parts, the Right Choice. MoparPartsGiant .com offers the wholesale prices for genuine 1990 Jeep Wrangler parts. Parts like Fuel Lines are shipped directly from authorized Mopar dealers and backed by the manufacturer's warranty. Parts fit for the following vehicle options. Engine: 4 Cyl 2.5L, 6 Cyl 4.2L.Jeeps, we have them ... Working on the gas tank on our 81'. I know it's fed up the passenger side to the pump on this and my CJ7'. I have a return ... OMIX Fuel Line Return Line for 76-83 Jeep CJ-7 with 3.8/4.2L ... OMIX Front Fuel Supply Line for 94-98 Jeep Cherokee XJ, Grand Cherokee ZJ & Wrangler YJ with 4.0L ... 1855 posts · Joined 2008. #5 · Jun 2, 2008. I just found out that the typical "fuel line hose" is now different, and you need special "fuel injection" fuel line hose. I use to pay 55 cents per foot for the old stuff, but today I paid nearly $9.00 for 2 feet of the f/i hose. I guess the PSI is quite a bit different (15 PSI vs 70 PSI), at least ...

dodger889. 4184 posts · Joined 2009. #2 · Nov 30, 2010. Large one is 5/16 and the return is 1/4. But the 5/16 will supply enough to run a 350 tbi. A 89 yj with a 4.0 aw4 sye out of an 92xj. Now the hard part is done time to get it up in the air just a bit. Working on 8.8 with 3.73 and lsd for the rear. and new D30 hp with 3.73 .May 20, 2013. #2. The fuel return line is in gold color, and is 1/4 inch. It starts on the drivers side at the gas tank, adjacent to the fuel line, sitting in a little recess in the frame. It goes around the shock tower, over the e-brake bracket, and around another the ebrake cable bracket, under the proportioning valve and stops in some place ...

If you suspect that the fuel return line is blocked, a simple test to do would be to remove the fuel return line and blow through it. If you can do this, then it is not blocked. Another test you can do is to put a fuel pressure gauge in the return line, run the engine through idle to about 1500 RPMs, and see what it reads.A lot of people have switched it to the route that you have shown because the gas runs cooler going under rather than over. Mine is sheathed in 5/8" heater hose to insulate the fuel line and prevent the gas from vapor locking. '87 YJ, 4.2L built and bored, 8" of lift, 8.8 rear, AX15/NP 231J, Tom Woods drive shafts, Flat fenders, 12,000LB winch ... 6100047. NUT, Clip Mounting. MSRP: $8.25. $5.62. Add To Cart. Genuine Mopar Parts, the Right Choice. MoparPartsGiant .com offers the wholesale prices for genuine 1993 Jeep Wrangler parts. Parts like Fuel Line are shipped directly from authorized Mopar dealers and backed by the manufacturer's warranty. Parts fit for the following vehicle options. #1 · Jul 23, 2014. Any particular tricks? Thanks! Like. Sort by Oldest first. MikeyinaYJ. 255 posts · Joined 2014. #2 · Jul 23, 2014. You could remove it and blow air through it or test …Tweet. #3. 03-04-2010, 12:17 PM. i just did a frame off on a 78 cj5 last season and if i remember correcty there are 3 nozzles on the tank on the front drivers side. one for fuel delivery to the filter. one is the return line and i think the third was an emission but mine was disconnected and plugged. yours being 75 might not have the third one ...The line coming from the pump (over the top of the motor) goes into the single nipple on the back of the filter, the nipple directly across from that (same diameter) goes to the carb, and the second nipple on that side of the filter goes to the return line. Your problem of starvation is probably from the dual filter setup, i had a 2150 MC on ...The hose that connect where the fuel pressure regulator is the return line. It acts like a plug that stops return if pressure is too low. '91 YJ Sahara 4.0L/AX-15/NP231, D30/D35 @3.07Fuel needs to move from the storage tank at the back of your Jeep to the engine, at the front. An electric pump in the tank lifts fuel and forces it into your Jeep YJ fuel line, through the fuel filter to clean it, then to the motor. Except for the under hood parts, most fuel system components are underneath your Jeep and exposed to the ...My thought is the feed will go to the fuel pump then to the larger output line from the fuel pump. Anyone have a picture of the fuel pump lines. Follow the line to the fuel filter. If it hooks to the filter, it is your pressure line (feed), if not, it is the return. 418 miles on 19 gallons of gas.#1 · Jul 23, 2014. Any particular tricks? Thanks! Like. Sort by Oldest first. MikeyinaYJ. 255 posts · Joined 2014. #2 · Jul 23, 2014. You could remove it and blow air through it or test …

Sep 8, 2011 · Ok, trying to determine how to run my fuel line from the filter to back of the jeep. Suggestions welcome. I bent up these new 3/8" stainless lines to follow the factory fuel routing. This is for an early GM 5.3 with a return line. Red line, follows the factory pattern, but will need a 90* fitting... Blue line, nice and straight, but behind the ...

Jeep YJ Fuel System for Wrangler (1987-1995) Your vehicle needs a steady stream of air and gas in order to conquer difficult unpaved terrain. The fuel system of you Jeep Wrangler YJ consists of a fuel tank, lines, pumps, sending units, filters, and injectors. If any one of these vital components fails, your vehicle may not run.

102 posts · Joined 2010. #5 · Jun 4, 2010. Located on the inside of the frame above the rear axle. Has its own shield with 2-3 bolts. Access from underneath. See location from stain on frame in picture. Ditto on the fuel lines. I found the filter after tracking a minor fuel leak from those lines.fuel lines on both the 93 parts Jeep (4.2L) and the 95 2.5L come up on the drivers side where the throttle body is. have you followed the line back to the tank to see …MoparPartsGiant.com offers genuine Fuel Lines, Front for 1995 Jeep Wrangler with great price and fast delivery. ... Fuel Return, Intermediate. 19. 52018810 TUBE, Fuel Supply, Front. 1994. 19. ... 52018478 BRACKET, Middle. 21. 83502745 O-RING REPAIR PACKAGE, Supply/Return, (Plastic Connectors Only) 5/16" Fuel Line. MSRP: $27.85. …22 Mar 2019 ... YJ Jeep Wrangler 2.5 Upgraded Fuel Injector Install(Eliminate stumble and hesitation). Full Speed Impulse•6K views · 16:12. Go to channel ...13 Mar 2013 ... Do any of you have a good picture of a return line setup on an amc v8? Is it 1/4"? Is it rubber all the way from filter to tank?In this video I am installing a fuel rail for a 95 jeep YJ wrangler, it is the 4 cyl 2.5l motor. The supply line is 5/16", Return line is 3/8". Quick connect...A Jeep YJ fuel line diagram simplifies this intricate design, providing visual clarity and aiding in easier component identification. Consider the Jeep YJ fuel line diagram as a navigational map on a road journey — It plots the path from your fuel tank (“home base”) leading up to the engine (“destination”), marking significant ...1324 posts · Joined 2010. #2 · Jun 14, 2011. For the '88 4.2 you should see the fuel filter inline just ahead of the carb. It should have an input line on one side and two outputs on the other. One goes to the carb and the second is a return line. When you put in the new filter, make sure that the filter is positioned so that the return line ...Nov 30, 2010 · dodger889. 4184 posts · Joined 2009. #2 · Nov 30, 2010. Large one is 5/16 and the return is 1/4. But the 5/16 will supply enough to run a 350 tbi. A 89 yj with a 4.0 aw4 sye out of an 92xj. Now the hard part is done time to get it up in the air just a bit. Working on 8.8 with 3.73 and lsd for the rear. and new D30 hp with 3.73 . Hi everybody, and welcome to my "stevenofpa" YouTube Channel!This video shows you what it's like to see this 1991 Jeep Wrangler YJ with the gas tank fuel tan...Anyone know which of the two hard lines that go into the fuel rail on a 1994 yj is the supply side (high pressure)? ... If I remember right the one with the regulator is the return line.. just not 100% on that. ~I'm really fond of sharp objects~ ... Truck and 4Runner Vehicles & Trailers Classifieds Axles,Tires & Wheels Classifieds Jeep ...

FUEL LINES, REAR YJ BODY. Fits: 1994 JEEP WRANGLER 4.0L I6 Power Tech, 5-Speed Manual | FACTORY CHRYSLER PARTS ... Use that for the pressure line and the regular hose will be more than fine for the return side. 2.5/ax5/ 231-300 doubler, Dana 60 front( 4ws springless double arm, tierod behind axle, 4ws springless driver side …The hose that connect where the fuel pressure regulator is the return line. It acts like a plug that stops return if pressure is too low. '91 YJ Sahara 4.0L/AX-15/NP231, D30/D35 @3.07FWIW: Fuel injected motors run at between 50 and 75 psi. The pump is capable of well over that. Don't screw with the factory setup unless you know what you're doing. 97 TJ Sport - 4.0/HP D30 w ARB/8.8 w LS/4.88s; 35s and flat fenders on 2.5 lift. 84 CJ7; frame off restoration in progress.Another lesser known factor one reaps when the return line recirculates unused fuel back to the tank is that the fuel doesn't get heat soaked setting in the line to get used. The engine "grabs what it needs" and sends the unused back to the cool gas tank for recirculation...less chance for engine vapor lock.Instagram:https://instagram. insignia roku televisionlittle caesars pizza camarillo menuused sulkysoldier field chicago seat map 137 posts · Joined 2013. #1 · Apr 15, 2014. Have been chasing a P0442 code and have changed out any suspect rubber lines and added hose clamps where needed as well as replacing the gas cap. I have noticed that my very rusty fuel vapor return line looks to have a few small seeps, showing wet spots on the line in the same consistent places. how much is a 2 dollar bill worth 2017van steenhuyse russell funeral home obituaries The hose that connect where the fuel pressure regulator is the return line. It acts like a plug that stops return if pressure is too low. '91 YJ Sahara 4.0L/AX-15/NP231, D30/D35 @3.07 pancake alley farmington nm The TJ fuel system is "returnless", it pressurizes the output line to the correct pressure and does all the rest internally. I believe the regulator is part of the "in …Holley 12-804 Holley Fuel Pressure Regulators. JEGS 41040 JEGS Fuel Pressure Gauges. Now you need fittings. The reg takes 3/8" fittings and the gauge takes 1/8" fittings. I got all of my supplies in the Home Depot fittings section. Two 3/8" nipples/hose connections and a 3/8" to 1/8" reducer. Install this after the filter as close to …Oct 17, 2006 · DougE. To the left you can see the stock filter with the return line feeding out of the top connection. The steel return line then passes between the carb and the valve cover. After passing the carb it transitions to a rubber fuel line and passes down to the driver's side frame rail passing by the brake line coils.